Harm to the consumer via fraud, and to the environment, yes. But corporations almost never see criminal charges. Fuck the environment for 6 years? Pay this fine. Sell some pot? Fuck you asshole go to jail for 3 years.
Agreed. This somewhat mollifying quote gives hope:
>"Using a defeat device in cars to evade clean air standards is illegal and a threat to public health," said Cynthia Giles, the E.P.A.’s assistant administrator for the Office of Enforcement and Compliance.
> California, the E.P.A. and the Justice Department are working together on an investigation of the allegations.
Though I hold similar pessimism to cmurf. If we can't even bring criminal charges against people that destroy the economy, I don't have high hopes for anyone being charged for destroying the environment (given the difference in priority they're normally given).
I would like to see VW prohibited from selling any vehicles in the US for a small number of quarters. That would be real punishment.
All those dealers and salespeople? There are a certain amount of cars that need to be sold. If VW is out of the mix, the demand is still there. The dealers can sell something else. I'm certain that Toyota and Ford can quickly come to some arrangement with those dealers, including any state legal issues.
If the cars can't pass smog testing without cheating, then they also need to be forced to buy each and every one of them back. $18 billion sounds reasonable to me. This needs to hurt.
Likely true; the problem with that is the owner ends up with a car with lower specs than they agreed to when they bought it. The owner of the car needs to be compensated.
Criminal charges seem like a good plan. But its not sufficient.
Volswagen has over a period of time pumped a lot of this gas into the atmosphere and the fine ought to reflect the actual clean up damage. What is it going to cost to remove it and put the environment back to the way it should have been if they hadn't broken the law. That is what these sorts of fines ought to be based on.
No fines should be punitive so they dont do it again. It is not about clean up with particulates, it is about their medical effects, which you cant be specific about.
My point was that a punitive fine was not necessary (as a deterrent or otherwise), but a fine that realistically represented the clean-up costs would already be enough. (Destroying such companies is fine with me.)
The board was quoted: "The members of the steering committee came to a consensus that, in the light of the past weeks, the mutual trust necessary for successful cooperation was no longer there"
What likely happened was that the EPA filed suit against VW in April, and in uncovering the evidence needed to support the suit, VW chair Ferdinand knew that he needed to go in order to let VW continue to be a company. Or, Ferdinand could have been the ethical one and blew the whistle.
Either way, let out the stink. Corporations aren't nearly the kind of flawless entities you think they are.
Corporations aren't flawless, but it definitely isn't a given that the people at the top have any clue what is going on with their software either. I can think of two instances that I've personally seen very similar to the referenced story where someone in middle to middle-upper management made the call, and only 1-2 devs/analysts had any idea what was done.
If anything that should go to show the lack of sophistication a lot of these projects have. There often is no project manager, no code reviews, and a messy codebase where snippets of very unethical logic can hide for years.
A large corporation...acting unethically? Say it ain't so! This is why regulations exist in the first place, because you can't trust companies to act ethnically on their own. Their job is to maximize profit, and the invisible hand only works on money.
I can't believe such a large company would cheat like that.
Companies, at the time when "company" was still being defined, used to do anything to exploit people and kill the environment just so their owners got a return on investment.
Only through the past 100 years of laws, regulations, and cultural refinement have corporations overtly stopped so many abuses of power. Some of the refinement is purely psychological manipulation as well ("Clean Coal!") and companies are still doing awful things to individuals, societies, and the world at large.
Our current generation is blind to many of these abuses because we grew up inside the bubble of "friendly companies." Friendly companies know they have to maintain their image. Friendly companies know they must hide their evil deeds from law/regulation because public relations now matters more than beating people with sticks to increase their productive output (because companies are immortal after all, you can't have the public turning on you).
GM knowingly declined to fix the safety problems with their ignition switches. This really killed people, not just violated some arbitrary local emissions number.
You are so right. GM didn't just kill a few people, they killed over 120 people:
General Motors agreed to pay $900 million as
part of a Justice Department investigation
into its failure to fix a deadly ignition
switch defect blamed for more than 120 deaths.
How would this benefit Volkswagen? The article says the device activates emissions control systems when it detects the car is being tested... so it's not as if they're saving money by emulating a system they're not manufacturing.
To pass the test with lower emissions. This means lower taxes in some countries, and good PR in every one. Edit: to expand this, consider that in order to reduce emissions like NOx, you often must sacrifice performance, so the customer will complain. When standarised tests were introduced, a crude counter strategy was to trade performance for lower emissions for X amount of minutes (the duration of the test). So customers noticed "hey, my engine works much better after 15 min!" :P
It's possible that the engine power / automatic transmission shift profile / maximum RPM / etc. is being manipulated to output less emissions at the cost of acceleration, top speed, ride comfort, etc.
The most fuel-efficient / eco ride is rather "boring" by the standards of car enthusiasts and reviewers and I guess the cars wouldn't be configured for that mode by default.
Or, you just pay more for a car that has those performance characteristics both in taxes/registration fees and in fuel.
That said, cheating like this is really bad on a very large scale, and should probably face fines and maybe criminal charges, unfortunately discovery is likely to fall outside U.S. juristiction so it would be hard to prove enough to bring criminal charges against the appropriate managers and executives.
Don't the emissions systems affect performance? I have a 2012 Golf TDI and really like it, one of the advantages over one of the hybrids is that I get pretty great fuel economy for the kind of driving I do, but it doesn't feel like I'm driving a weed eater.
This really pisses me off. It doesn't surprise me I guess but it never occurred to me that a car manufacturer could get away with something like this for, apparently, 6 model years.
Yes, a common strategy is to inject more EGR (exhaust gas) into the fresh intake air. As EGR is already burned, it is inert, so it negatively affects the combustion, lowering the temperature. With lower combustion temperature you get less NOx... but less power for each amount of fuel, so your efficiency/performance is lower, and also non burned products (CO, C) increase. You then trap those with the Diesel Particulate Filter... it's a very complicated game with very small margins, that's the reason of so much cheating.
Since this EPA action is about NOx, it seems VW will need to lower combustion temperature, leading to higher soot and therefore more particulate filter cycles. That will also increase fuel consumption.
EGR on a diesel also terribly gunks up the intake manifold downstream of the EGR introduction point. For that reason (and the loss of power and efficiency), it's often defeated.
Reducing emissions usually comes at the expense of worse power or fuel economy.
By only reducing emissions during testing, they can demonstrate better engine power and fuel efficiency while also claiming to meet the emissions requirements.
The VW/Audi 2.0t EA888 engine is capable of producing 100 more hp with a software update. These turbo/diesel/supercharged engines have a million parameters that they can modify to change driveability. I cant believe that they would do something like that to pass emissions testing though, that seems incredibly foolish. I would imagine that with diesel engines, economy and certain emissions are at odds with each other.
They are, in particular the higher the in cylinder combustion temperature the higher the efficiency, and the higher the NOx production. This caused heavy diesels to get less efficient for a few years when NOx stringencies were tightened. Then they were tightened far enough to require catalytic reduction, and manufactures went back to high efficiency high NOx combustion and removed the NOx downstream.
Help sell cars. I have a TDI sportswagon and this will be the second performance hit. A couple years after purchase there was a recall to reduce the power a bit via software "upgrade". Seems fuel filters were occasionally failing at high acceleration or with people that used high acceleration a lot. The power drop was minor but noticeable. I suspected then and even more after this indecent that VW knew about the problem but wanted max power to help sell cars during the test drives.
I research for the auto industry and this was very well known by the authorities. Fixed test cycles like the New European Driving Cycle https://upload.wikimedia.org/wikipedia/commons/thumb/d/dd/Ne... were easy to detect, and easy to optimize against. That's why coming regulations introduce more realistic cycles like WLTC https://upload.wikimedia.org/wikipedia/commons/thumb/b/be/WL... and real road tests, where particle emissions will be trapped and compared against the lab test, and only a certain % of deviation will be allowed (last time I looked they didn't decided this % yet).
I hope this gets fixed, although I don't believe it. I care about the noise emissions. AFAIK they are measured on a real road, but only up to 50 km/h and in a ridiculous narrow test.
Harley Davidson and other are known to optimise for this test with movable parts in the exhaust pipes so these get much louder when the bikes goes faster than 50 Km/h.
I actually work on aeroacoustics! My specialty is turbomachinery but regarding combustion noise, let me say that it is a very tricky subject... even slight variations on the fuel injection settings and valve openings can have a high impact on noise!
Well, as much as a cheat it is, I'm happy that those bikes can go quiet on slow (city) streets but as loud as possible on the highway (increase security and swag).
I'm a motorcyclist and I'm downvoting this fallacy. If this were seriously the case then good beginner bikes like the Ninja 250 and Honda CBR250R would be unsafe, especially for new riders. Enjoy your loud pipes if you like (I do on my throaty Aprilia) but don't pretend they give you any safety benefit to balance the annoyance it causes some people.
I too am a motorcyclist (85K miles of sport bike riding, Sunday morning ride to Pt Reyes was a lot of that, current stable is r1200gs and wr250r).
I despise loud pipes, just frigging hate them. But I live in deer country (Santa Cruz mountains) and I've hit a deer at speed on the GS (did not wipe out, lifted the front end and had my front tire hit it square in the hind quarters, spun the deer around, I dropped the front wheel down and did a very shaky coast to a stop. My hands were shaking like a vibrator on steroids).
After that experience I really wonder if loud pipes would have scared the deer off. I tend to doubt it, I've not installed a louder pipe, but it's made me less pissed off at the loud pipe people. Not a lot less pissed off, but some.
BTW, shoutout to the Ninja 250 and especially the 500 version. I had two of the EX500's and those were by far my favorite sport bikes. Lots of torque, could pull any 600rr off the light (yeah, the 600 was blasting by me 2/3rds of the way down the block, but do you really want to ride a sewing machine? I don't. Loved my 500 twins.)
I despise overly loud pipes - like, you have to scream loud.
But,Ive been riding a bike a lot as well.
Way too quiet exhausts (like EU is constantly pushing on us) are dangerous - ive seen it myself - my dad with a louder exhaust passes with no issues and I, silently, get cut off and nearly run off the road by a guy that assumes that mirrors are for pussies.
It happened quite a few times already.
Annoying lights help. I ride with some quite bright led lights I got off of advrider.com and I think they help. You could get the flashy kind that bicyclists use, those definitely make them more visible.
If you are in a modern EU/Korean/Japanese car, you would have to be rather unlucky or going fast if anything was to happen to you. Also,it takes a lot more to actually drive you off the road - you can literally push back.
On a motorbike all it takes is a bump,and, you have to be lucky not to end up in hospital.
Btw in no way im for window rattling. However, EURO4/5, I would not be surprised if my vacuum cleaner was louder
TL;DR - I stand by my comment, loud bikes helps people hear you but that doesn't mean you have to be EXTRA LOUD to be cool.
I understand the point you are trying to make, and perhaps I wasn't very clear in my off-hand comment. I agree that overly loud bikes are annoying, however, as I stated before, sound is a necessary evil[0].
Do I believe that motorcycles should use straight pipes and increase their sound output? NO, in fact its quite annoying. However, louder bikes will get your attention.
In fact, in reference to [0], there is a standard that some vehicles had to INCREASE their decibel output because of less risk to pedestrians. This isn't an apples-to-apples comparison as this study was mainly geared towards electric vehicles, but it did state that vehicles should have an output of ~ 55dB for pedestrian safety (page 102).
Secondly, I couldn't find good stats on motorcycle decibel output, but I did find a study of some motorcycles and their average output[1]. What I learned is that most bikes are fairly equal with regard to output and all are at, or above the, legal limit[2].
I took a single bike you pointed out `Honda CBR250R` and was curious how the noise output performed to a Harley:
`Honda CBR250R`: [3]
- With dB-Killer fitted: 86 dB @ 4,250 rpm
- Without dB-Killer fitted: 94 dB @ 4,250rpm
2006 Softail Standard 1,400 cc: [4]
- 97 decibels at idle
- 102 decibels at cruising speed
- 111 decibels revved
So what it appears to me is that most motorcycles are `roughly` the same decibel output and that having a vehicle that outputs sound to make yourself known to other riders is beneficial. Should you be increasing the sound trying to be cool? No, I don't think so. In fact its annoying when the 5 Harleys are sitting outside my window on Friday night revving their engines to be "cool".
One, decibels are a logarithmic unit. Two, you are comparing factory exhausts on the Harley meant to comply with noise regulations with top of the line aftermarket race exhausts for the Honda (which is probably as loud as you could make the Honda without removing the pipes entirely). They are not anywhere near each other - and the data in [1] really makes that point, I'm not sure how you concluded that most motorcycles are anywhere near each other in sound output.
That's not a good statement. Just because a number is logarithmic does not make sound logarithmic...Here is a video that shows two different exhaust with similar dB output: https://www.youtube.com/watch?v=Ax6W-V9bsmg
> Two, you are comparing factory exhausts on the Harley meant to comply with noise regulations with top of the line aftermarket race exhausts for the Honda (which is probably as loud as you could make the Honda without removing the pipes entirely). They are not anywhere near each other - and the data in [1] really makes that point,
My parents live in the country approx 1/2 mile from a fairly busy 2 lane highway and the location of their house would be perfect if not for the fact that Harley-Davidson makes motorcycles. In the evening the sound of all the other traffic on that roadway pales in comparison to that of Harleys. To be fair, some of that distinction is probably due to the fact that a big twin seems to produce a noise signature that [regardless of the reported same DB output claims] carries much further than other types of engine configurations. But also I suspect that a large number of HD riders, because of 'safety' logic or ego or whatever, spent their first extra $400 after purchase on a new set of louder aftermarket pipes. The net effect is that they henceforth serve as 'ambassadors of alienation' for most people. Ducati and Buell riders don't seem to have the same fears or need for special recognition.
+1 here. I have two bikes: one is a custom tracker (read: bunch of parts bolted together into something that runs... mostly) with open pipes. The other is a Zero SR (electric). Although anecdotal, I notice no difference in driver perception of my presence, except in stand still traffic, where it is least needed.
With the level of acoustic engineering that goes into modern vehicles specifically to block out external noise, combined with radio / in car entertainment, relying on other drivers being able to position you from audio is a bad idea. Now if bikes were to be fitted with cell phone jammers, that I could get on board with.
Like your spirit (I don't like the loud pipes either) but this is a little unfair. Motorcycling should be part of a more sustainable future. Especially when you consider how many OECD commuters commute in cars alone.
I don't think motorcycles are actually so unsafe that they need to be that loud. But rather than argue about that, I'd rather point out that massive noise pollution isn't a fundamental right, so "we must be that loud to ride" is just saying "we shouldn't ride."
Motorcycling is 45 times more likely to result in death than driving in a car.
Electric vehicles are sustainable, motorcycles are death traps that can't be made safer (said as an ex-owner of a Katana, and both a Yamaha R1 sport bike and Roadliner cruiser).
I agree with the parent. I despise motorcycles for their noise. On a nice spring/summer/fall day, it can be quiet and peaceful where I live (small community of 120k). More often than not, though, that quiet is ruined by a loud annoying motorcycle.
I'll be happy when motorcycles are electric, and therefore silent. If your vehicle can't carry you safely without being unnecessarily noisy, then it just shouldn't be on the road.
Wait, why are motorcycles important? They're inherently less efficient, netting out roughly the same environmental impact --- assuming modern motorcycles! --- but without the ability to carry passengers or significant amounts of cargo.
Maybe in the west where motorcycles are more of a leisure transport than a mode of commute, but in developing countries bikes with small engines in the ball park of 100 cc (the honda cub for example) are definitely some of the most efficient modes of transportation. In India i could get a bike that could comfortably get around 60kmpl in normal driving conditions ( 3 bikes with 6 passengers total would be about the same as a prius at about 1/10th the cost). And in a congested city, no other mode of transport beats it (unless the city has a very well connected metro rail transportation)
Except when you're in my blind spot, and your pipes are pointing backwards, I still won't hear you until you're in front of me and I've already seen you. Cars are incredibly quiet inside these days.
I understand that concept that "Your pipes are pointing backwards so the isn't helping with making people aware of you in the front". From my research, it seems that most motorcycle accidents occur with a driver crossing, to the left, in front of the motorcycle and that the decibels, horn, and lights didn't help the driver (of the motorcycle).
I also agree that you don't have to make your bike EXTRA loud to be noticed but there is a perceived safety in sound. And if majority of the sound is exiting towards the back, there might a point to be made that the decibel level should increase to "hopefully" make the person in front of you aware.
Something vital is lost in motorcycling that my bike is so loud to make children cry and people really detest my presence everywhere in the name of saving my fat posterior.
All my bikes are quiet, even my Buell (relatively speaking). I have installed extra loud horns on them and I'm not afraid to use them. That's what horns are for: to say "I AM HERE", nothing more, nothing less. Save your engine for moving the bike forward, not making all of us bikers an anathema to civil society.
I agree with you, and I wasn't referring to ear piercing noise of modified bikes.
However, as I answered in a response to one of the other commenters, sound is an essential element in bringing awareness to yourself.
`All my bikes are quiet, even my Buell (relatively speaking)`
- From what I've found in my short research is that most bikes are in similar decibel level output (within similar engine capacity) and that they are all fairly loud. Clearly there's something to that.
But I degrees, I never meant to say that you have to be extra loud to be an ass, I was merely pointing out that sound is an element of awareness, like your horn or the headlight.
I completely agree with you! I live in an area where on Friday and Saturday nights there are always groups of 5-6 bikers sitting outside and just revving their engines to "sound cool" and that's very annoying.
I didn't meant that you had to be extra loud or replicate the idiotic behavior of our neighborhood bikers. I was merely pointing out that loud sounders are safer. I had a more detailed reply above.
So right, too much noise = bad. Just enough sound = maybe good.
This is the silliest thing I've read all day. For starters, you're implying that drivers have less need to perceive small bikes...or other cars, apparently.
My reply comment wasn't very detailed and gained some criticism that I understand.
You make a valid point "... implying that drivers have less need to perceive small bikes...or other cars, apparently."
As I stated above, but will re-iterate because its a valid reply here, there seems to be a necessary of roughly 55db produced by a vehicle to ensure safety for pedestrians and other vehicles. [0]
My initial comment was incomplete: it's not okay to have an extra loud bike to be "cool", however, it is important to have a high enough decibel output that other people can hear you. Most bikes produce similar dB off the manufacturing plant for a reason and electronic vehicles are required to output more sound to be safe.
So no, i'm not implying that drivers have less need to perceive small bikes or other cards. I'm implying that all vehicles should produce the necessary decibel output to bring attention to themselves.
I'm a motorcyclist too, and straight piped Harleys make me stabby. I don't believe they're louder on the highway. I believe they're louder whenever they're within earshot of any place where people congregate without earplugs (cafes, restaurants, pedestrian areas), whereupon the scumbag on the seat finds it necessary to go wide-open throttle to show off how terrible their bike sounds. It never fails.
"Ozone is a powerful oxidant (far more so than dioxygen) and has many industrial and consumer applications related to oxidation. This same high oxidising potential, however, causes ozone to damage mucous and respiratory tissues in animals, and also tissues in plants, above concentrations of about 100 ppb. This makes ozone a potent respiratory hazard and pollutant near ground level."
I don't understand how California detected this. The one time I had to take my 2010 Jetta turbo diesel for a smog check, the inspection was ENTIRELY visual. The inspector did not insert a probe into the tailpipe. He did plug the test rig into the OBD-II port under the steering column and turn the key to the accessory position (presumably to electronically capture the VIN), but that's it. I even asked him at the end if it was an entirely visual inspection and he said, puzzled, yes but that's what the computer told him to do.
I'm not sure about CA specifically, but some states only do full inspections on newer vehicles every other year. e.g. In a particular year the odd year models get the full inspection and the even year models just get a quick inspection and then vice versa in the next year.
ca doesn't even do smog checks on newer vehicles (i believe 5 years, not sure though).
i haven't done one in over a decade because i lease my cars as a business expense.
also, ca has 'test-only' smog centers which do not perform repairs - if you fail there, you have to get your car tested and repaired somewhere else.
needless to say ca highly incentivizes you to buy new clean cars. it quickly becomes very expensive to fix an old, polluting car under this regime. imagine how fast the bills can pile up if the first or second fix doesn't work. with new econo class cars available for ~$100/month on finance or lease, it doesn't really make sense to keep an old clunker around unless it's a collectible.
Interesting to note is that 1997-older diesel trucks/cars did not and still do not require any smog testing at all.
"Currently, smog inspections are required for all vehicles except diesel powered vehicles 1997 year model and older or with a Gross Vehicle Weight (GVWR) of more than 14,000 lbs, electric, natural gas powered vehicles over 14,000 lbs, motorcycles, trailers, or gasoline powered vehicles 1975 and older."[0]
i had to do a smog test for my 1 year anniversary of owning a new car. it is a 2015 model from a different manufacturer, acura, in my case, and it was visual inspection only. i asked the guy, because i'm used to having actual measurements performed each time. if a car is new enough then they only do a visual inspection. i don't know the details of how "new enough" is determined, though.
i've seen this also when having fire extinguishers inspected; ones that are only a year or so old are also only visually inspected only.
In NY the first year is safety only; but year 2 and on are emissions + safety (depending on the county you register your car in, some never need emissions). The safety inspection only costs $10; IIRC the emissions + safety is $37.
Colorado does drive-by testing, on freeway on ramps, and other locations with high traffic. If your car fails, or hasn't been monitored by that system recently, you get a notice for the more complete inspection.
The drive-by inspection doesn't require the co-operation of the driver or car, so is harder to game by detecting you are being tested.
As a TDI owner and Colorado resident, I can tell you that the drive-by testing does not apply to diesel vehicles, nor do you take diesels to the emissions testing centers. You have to take your diesel to a state-licensed diesel mechanic for testing.
Here in Oregon my '03 TDI gets a quick ODB-II and a visual inspection (i.e. is the Check Engine light off, is the exhaust not full of smoke, etc.). Of course, I'd expect CA to be the most stringent state.
California's CARB is the gestapo of car emissions. If anyone has the motivation, expertise, and evil disposition to detect this, it's the state of California. I've never lived in a state like this. Bi-yearly tailpipe sniffs and visual inspections. Even if your car's emissions are cleaner than their ridiculous requirements, they'll still fail your car if it has parts on it that are not stock. I ended up having to sell my car to someone out of state because I'm not going to swap in and out my carefully customized (and clean) intake and exhaust system every two years just so they can shine a flashlight in and see stock parts.
I'm not shocked that California is a part of this.
On the contrary, California emission standards held diesel passenger vehicles to the same standards as gasoline/petrol passenger vehicles. Whereas in Europe, diesel emission standards were much more lax compared to their petrol counterparts.
I suppose one could say that being more concerned with the more directly harmful and smog forming emissions(NOx and PM) over CO2 would constitute 'bias' against diesels. But, conversely, there's a rather compelling argument that the more lax European diesel regulations spurred diesel adoption and protect their domestic manufacturers.
A lot of jurisdictions in Europe are rethinking their diesel prioritisation a precisely because of particulate and Nox emissions.
In the case of Volkswagen, the TSi engines are a much better buy than the TDi engines. Better power delivery, clean running and nearly as good fuel economy.
ryandrake's point was probably that his car is cleaner than necessary, but failing because of stupid, arbitrary rules imposed by CARB for no reason other than bureaucratic intransigence.
It's similar to the feeling I got when I waited in line for an hour to have my Miata smog-checked at a busy urban test station, and then choked on diesel exhaust from a dump truck when I made the mistake of driving away with the top down. CARB is the poster child for "Doing something just to say we're doing something."
Should we fault CARB though? They require more stringent emissions regulations due to California's geography, and both the federal government and automakers are rarely amiable to their needs.
With cars going electric, its a bit of a moot point, except for the part where pressure needs to be applied on heavy trucks now (hopefully pushing them to natural gas from diesel until energy storage catches up).
I'm still not being clear, I'm afraid. It's not a question of how stringent the emissions specifications are. The problem is CARB's reliance on equipment checks rather than tailpipe emissions checks. ryandrake's car might well be cleaner than a perfectly-stock vehicle, but if each and every component doesn't have a CARB certification number stamped on it, it's illegal.
You could argue that equipment checks are in place to prevent the very situation described in this article, where people might install shady aftermarket hardware to game emissions tests, but as we've seen, the aftermarket is not where the problem actually lies.
Bureaucratic intransigence is a really upbeat way of putting it. How about corruption through regulatory capture? Big auto needs to sell their over-priced parts. Why let people buy a $150 after-market part, when you can just call up CARB and have them make people buy equivalent $1,100 factory or OEM parts?
Wow, judging by the down-votes, people don't seem to realize how expensive CARB deliberately makes it to own an older car, regardless of how clean its emissions are.
EDIT: To further demonstrate that it's all about money and not about smog, you can get a "Repair Cost Waiver"[1] if you've spent at least $650 (on CA-approved parts, of course), and they'll approve your polluting car, no problem. All they really want is that $650 in the pockets of their car industry buddies and $XYZ worth of repeated tests in the pockets of the test stations.
> Wow, judging by the down-votes, people don't seem to realize how expensive CARB deliberately makes it to own an older car, regardless of how clean its emissions are.
I upvoted you even though I disagree with you for what its worth.
You're an edge case. Most people with older cars no longer maintain their emissions controls. The older the car, the more likely it is that its polluting. Is it fair? Not at all. You're just swept up in the process.
Cars built since MY 1996 are self-diagnosing for most emissions problems. Mandating factory-original parts simply means the auto manufacturers won a major political battle, not that anything effective is being done.
Many of those self-diagnosing features can be defeated by trivial circuits. A 555 timer for a downstream O2 sensor, a 4N4001 diode and a couple resistors for an EGR vacuum sensor hack, and several others.
I have had cars in the past that OBD2 reported as operating correctly, that easily passed smog/inspections, that probably weren't operating as the EPA intended.
But how many people with older cars have the initiative and the the capability to do that. It's a small fraction of a small fraction of a small fraction of vehicle owners.
Chasing a problem like that around is a waste of everyon'e time and money. Environmental regulatory agencies really need to do a better job considering the 90/10 or 80/20 rule (the last 20% of whatever you're optimizing will consume 80% of the resource).
At what expense/frequency, though? If it's just to cover the ocassional (unmodified) car that can't be made to report as "Ready and OK" per OBD2, it's just easier to use the existing repair exemptions process. (Spend a certain amount on repairs and get another cycle of inspection passage.)
If it's to cover modified cars, those are a trickier situation. It's easy for some to game the system so that it "passes" on the magic day and then fails the other 364 or 729 days in the cycle when it's actually being driven.
In either case, it seems like the expense of operating and staffing gas sensing stations, rolling road dynos, etc. Probably better to just turn a blind eye to that case as well.
You're not wrong, but tailpipe tests were quite common in many states. In CA, like other states, they're being phased out.
Nevermind the fact that California has no safety inspection, unlike many Eastern states in particular. It's fairly silly to call CA the "gestapo" although they are more aggressive about emissions than anyone else, as you mentioned.
I am a driving and motorcyclist enthusiast, and have modified cars and regularly participate in track days. Somehow I've never had a problem with CA emissions, nor have most of my like-minded friends. It's just not that bad, and it does a lot of good.
California has a new emissions check system for vehicles 2000 and newer. No tail pipe probe or dyno regardless of the vehicle. Just visual inspection and plug in the OBDII reader. The OBDII reader checks the sensors for proper functioning and checks the ECU to make sure it hasn't been tampered with. Smog tech only really has to do the visual chek. Diesel trucks also get a snap test (step on the accelerator quickly and diesel smoke must dissipate within several seconds).
Vehicles 1999 and older still get the tail pipe probe and dyno portion as well as the OBDII (if they have OBDII).
Yea, they do get the tailpipe emmissions test. Most shops use just one reference book for the visual inspections.
The shop owner usually, almost always, buys the $100.00 Motor Emissions manual.
The cheap shop owner should buy OnDemand5(Mitchell Manual Smog Emission) subscription/publication. They don't because they are cheap, and CARB only requires one reference manual for customers, and technicians.
The problem is Motor Publications is filled with errors that send thousands of customers home with failed Smog Checks.
I have found so many errors in Motor publications, it's comical. I have numerous emails, where I am literally arguing with, I believe, a secretary, over errors in their manuals. I have one email when the person I'm communicating with doesn't know the difference between Naturally Aspirated(Carburated) v.s. Fuel Injection. It's beyond frustrating, and I hope they get sued!
If you live in California, and your car doesn't pass the visual smog check, it's probally not you--it's errors in Motor Publications?
I have found errors on older Toyotas, and Volvos. Just the two autos I happen to own? What are the odds of that? They failed my vechicles, until I went to a shop that had Mitchell manuals, and I presented the Techs with a Printout of the Correct Emmission information.
(Motor Emission manuals--If you are listening; please clean up your books? It's beyond frustrating to fail a smog test because of your sloppy research! I will show the world my frustrating emails--if necessary?)
(CARB--if you are listening, require every shop to have access to two (2) separate Emmission manuals from different entities?)
And no--1988 Toyota trucks, 2wd, naturally aspirated(Carburator) do Not require a MIL light.
I literally tore apart the dash looking for the missing light. There was no light. There was no plug for a light. I literally thought I was going crazy. I was so frustrated, I forget to set the emergency brake and the truck rolled out of the garage. I'm lucky I wasen't on a hill and no one got hurt. I did need to buy a $200 bumper though. I'm still thinking about taking the shop to small claims court, but don't think it's worth the effort?
So, if you live in California, and fail Smog--ask questions.
Don't just bring it to another Smog testing station praying it will magically Pass.
Naturally aspirated means the engine breathes air at regular atmospheric pressure - ie is not turbo or supercharged.
The type of fuel delivery has nothing to do with whether it is naturally aspirated or not. A NA engine can have fuel injection and a supercharged engine can have a carburettor.
California didn't originally detect this. According to the letter from the EPA [1], it was a team at West Virginia University doing a study that discovered that TDI's in normal usage were found to have significantly higher emissions. California's CARB then dug into it to confirm their results and work with the EPA to figure out what was happening.
They even made commercials to prove how clean the cars are. https://www.youtube.com/watch?v=WNS2nvkjARk
I own a TDI VW and fell into believing that the ride is indeed clean. Now it looks like their software hacks are even more refined than the combustion tech.
Of course this is a major part of their marketing. If the EPA makes them reflash my ECU and as a result my fuel consumption goes up noticeably I'm going to expect them to buy the car back. They sold them on false claims.
This also pretty much guarantees that I will never buy another VW.
If they face a choice between having to pay an EPA fine equal to the original sale price of the car, or buying them back at depreciated values, I can imagine which one they'd prefer.
When I last bought a VW (2008) I was concerned due to a clunking noise after first starting it up and driving a few miles; I called the VW service dept and they explained that there was a compressor which captured exhaust fumes and released them at a lower rate for the first few miles of each journey -- to help them meet EPA emissions standards. I was assured there was nothing to worry about.
While this is a different case, it struck me then that the emissions guidelines were being gamed by manufacturers. We're regularly reminded that barriers will be circumvented; what is the correct approach here? Like performance enhancing drugs in sports, too stiff of a fine and manufacturers are encouraged to find more subtle ways to beat the system, unenforced you leave a polluting industry to destroy our environment..
That's a poor comparison. Not all of the $30B in sales were fraudulent.
Actually, in order to come up with the $2B penalty, the gov't determines the number of fraudulent Rxs, then hits the manufacturer with triple damages (this is typical).
J&J would have been better off financially had they never committed the fraud they did.
You need to account for the probability of being caught. It's quite likely to be significantly lower than 1/3, so they might still have come out ahead.
Even if they're just breaking even, it's a kind of loan - they had the gain a long time ago, and pay the costs much later. If you're a risky business, that's potentially worth a lot, since investors might be hard to find.
And if you account for that you need to account for the asymmetry of risk due to bankruptcy protections - even if the average payout is negative, fines are effectively capped at what the firm can pay, so the effective expected payout may still be positive. (Assuming those making this decision escape personal liability).
Of course it is. Companies usually behave rationally with regards to regulation and punishment. If the cost of breaking the rules is lower than the cost of following them, companies will break the rules. If you increase the cost of breaking the rules such that the situation is reversed, then companies will follow the rules.
That's not a good idea. If you ban a large auto maker, you might create a shortage of vehicles, driving prices up for consumers. Also, the affected auto maker would surely try to mitigate the damage by cutting costs, closing down factories, firing workers. Dealerships would have to close as well.
In other words, you would cause a lot of collateral damage instead of taking it directly from shareholders via a large fine.
Every time you arrest a parent for committing a crime, you destroy a part of their child's life. Using collateral as justification to avoid punishment results in a system where entities can become to important to punish at all.
We're talking about how to punish not if. If you can punish a parent in a way that does not affect the child, surely that has to be preferred way of doing it.
So we accept differential treatment based on one's having kids? What happens if the better punishment from the kid's perspective is actually worse for the parent?
I think that courts do take individual circumstances into account and must be allowed to do so. I don't deny at all that it can be unfair, but I don't think inflexible rules like three-strikes sort of laws or draconian minimum sentences that take away the judge's wiggle room are any fairer.
A prison sentence for a parent is not just hurting the kid more, it's also much harsher on the parent. You're not only taking away their freedom, you're also taking away their kid. In effect, that is differential treatment as well. But I will admit that I'm not comfortable with this line of argument either.
The case of auto makers breaching environmental rules is much simpler though as a large fine that does not cause factory and dealership closures or price hikes is better in every imaginable way.
>I don't deny at all that it can be unfair, but I don't think inflexible rules like three-strikes sort of laws or draconian minimum sentences that take away the judge's wiggle room are any fairer.
So what happens when punishments begin to show an even stronger racial bias. For example, the argument that a white offender is safe to release because they are more likely to get a job which reduces their chance of committing a crime. Never mind that they are more likely to get a job because of institutionalize racism in our society.
>You're not only taking away their freedom, you're also taking away their kid.
A prison sentence for a rich individual hurts their income far more (and they are less likely to engage in crime once they are out due to higher education and better ability to find employment), so rich people should only be given a fraction of the sentence... the conclusion using this line of reasoning do seem to end poorly.
>The case of auto makers breaching environmental rules is much simpler though as a large fine
Except it attached a price tag to breaking the law, which fundamentally changes how businesses approach the law. Imagine what would happen if every crime was fined a fraction of what it earned you.
>So what happens when punishments begin to show an even stronger racial bias. For example, the argument that a white offender is safe to release because they are more likely to get a job which reduces their chance of committing a crime
That is but one possible argument of many. A judge could also make the case that locking up hugely more members of one racial group than of others destroys the social fabric of society, creates even more crime in the next generation and is ultimately worse for everyone.
So yes, you could ask many questions of that sort and you are right that giving judges room to weigh individual circumstances can go both ways. In my opinion, not having that wiggle room is cruel and relies on a completely unjustified confidence in the ability of law makers to forsee all the situations that might come up.
>Except it attached a price tag to breaking the law, which fundamentally changes how businesses approach the law. Imagine what would happen if every crime was fined a fraction of what it earned you.
Banning an auto maker for 12 months in one particular country has a price tag too. Every punishment of a corporation can be distilled down to a mere price tag. Whether or not the price tag of a ban is higher or lower than any fine depends on the amount fined.
There are many problems with outright bans. It is a very inflexible and crude tool. It does not allow for a gradual and measured punishment that fits the extent of the violation. It does not bring money into government coffers or into victims pockets. It cannot be applied equally to every company in the same way if at all. You cannot simply shut down banks, utilities or OS vendors without destroying the entire economy. We do need some degree of pragmatism that limits collateral damage.
Also, we have to acknowledge that corporations are not people after all. The corporation doesn't take the decision to violate some law. Executives do. So if you want to go beyond a price tag for certain kinds of violations then you need criminal prosecution of individual executives on top of fines.
My argument is that you shouldn't. Time in prison should be equal, regardless if you are a poor homeless guy who committed the crime or a filthy rich mutual fund manager whose fund will lose massive amounts of value.
Agreed. If auto makers face the risk of significant fines and/or penalties they will have to spend more on compliance. The worst thing for innovation is to create an environment where engineers are effectively being managed by lawyers and accountants.
Perhaps the noise was poorly explained. What they describe is likely the Exhaust Gas Recirculation (EGR - https://en.wikipedia.org/wiki/Exhaust_gas_recirculation ). This isn't a system to game emissions, it's an active component in real emissions reduction.
Still I get your point: manufacturers are clearly going to optimize based on the measured metrics. How do we know those metrics are meaningful in the overall system.
ERG is just a pipe from the exhaust to the intake with a valve. Compressing and carefully releasing would be much more complicated and very much a not normal way of lowering exhaust temperature to reduce emissions.
Yes, on second thought, they probably confused secondary air injection ( https://en.wikipedia.org/wiki/Secondary_air_injection ) with EGR. It's very possible they were explaining secondary air, which doesn't compress exhaust gas, but does inject air into the exhaust gas to help burn more efficiently (not clear on the mechanism, I always thought it was a method to improve catalytic converter efficiency at startup).
I owned an RX-8 which had an air pump (secondary air injection) which would come on for about 30 seconds on a cold start. When the pump started going out, it would make a metal grinding sound. Drove like that for a few years until it quit working, and didn't think anything of it until SMOG time - $600 for an air pump which works for ~30 seconds...
I think the idea is that cold engines run rich, so injecting air into the exhaust gives the unburnt fuel a chance to combust in the exhaust pipe before getting to the catalyst. This is good for two reasons, first, it heats the catalyst up faster, which is good, and it also reduces the amount of unburned hydrocarbons.
When engines are colder, they burn less efficiently and produce "worse" emissions. A system that treats the warmup period differently than the steady-state of running a hot engine is potentially quite reasonable.
If you output those same emissions at a different time you haven't really done a lot for environment (except if they're cycled through catalyc converter or DPF filter which are usually less effective on cold start) - you're just gaming the system to get better eco ratings.
If you're recirculating exhaust back into the engine, you're able to attempt to reburn any fuel that wasn't burned on the first pass, while also exposing any emissions to higher temperatures on the second pass (higher temperatures = easier to break down when those emissions reach the emissions control system).
If you're recirculating exhaust back into the engine, you're able to attempt to reburn any fuel that wasn't burned on the first pass
That's not what EGRs do.
EGRs take exhaust, which is relatively inert (combustion having already taken place) and injects it into the combustion chamber to lower combustion temperatures. The reason you want low temperatures is that NOx (nitrogen oxides) form at high temperatures.
"In internal combustion engines, exhaust gas recirculation (EGR) is a nitrogen oxide (NOx) emissions reduction technique used in petrol/gasoline and diesel engines. EGR works by recirculating a portion of an engine's exhaust gas back to the engine cylinders. This dilutes the O2 in the incoming air stream and provides gases inert to combustion to act as absorbents of combustion heat to reduce peak in-cylinder temperatures. NOx is produced in a narrow band of high cylinder temperatures and pressures.
In a gasoline engine, this inert exhaust displaces the amount of combustible matter in the cylinder. In a diesel engine, the exhaust gas replaces some of the excess oxygen in the pre-combustion mixture.[1] Because NOx forms primarily when a mixture of nitrogen and oxygen is subjected to high temperature, the lower combustion chamber temperatures caused by EGR reduces the amount of NOx the combustion generates (though at some loss of engine efficiency).[2] Gasses re-introduced from EGR systems will also contain near equilibrium concentrations of NOx and CO; the small fraction initially within the combustion chamber inhibits the total net production of these and other pollutants when sampled on a time average. Most modern engines now require exhaust gas recirculation to meet emissions standards."
That's traditional "external" egr. Many newer engines have an "internal" egr implementation, which just changes valve timing so that some amount of the combustion products are never evacuated from the cylinder in the first place. With cam phasing becoming commonplace, internal egr can be implemented without adding any additional parts, and is thus cheaper. So the "recirculation" part of egr is becoming more and more of a misnomer.
Personally I like internal egr because external egr systems have a tendency to clog in either the passageways or the solenoid controlled valve. EGR valve sticking is a common cause of cars stalling when slowing to a stop after cruising at medium-high speed. And even without the stalling egr is a common cause for check engine lights and smog test failures.
Car makers work hard to get emissions to be as stable as possible in all running states. For instance, cars have an air injection pump for the purpose of getting the CC to do its job sooner by increasing the temperature of the exhaust gas. It starts at a high RPM when you first cold start the engine.
EPA is well aware of warm up requirements. This is not a warm up cycle, it is a non-representative fuel map that alters performance from what they certify specifically for the EPA test cycles.
>the emissions guidelines were being gamed by manufacturers
Not necessarily gamed - the measuring just needs to factor it in. e.g. (Rather anecdotal) I know there are cars programmed to capture emissions in a filter & then automatically clear that when the car reaches high speeds (freeway). Makes sense in a way...you'd rather have the car expelling the crap on the freeway than city center. That mechanism is apparently a big problem here - I live in a place where the cars never reach freeway speed so they keep clogging (so I'm told).
I believe you mean the EVAP system where excess gasoline vapor is condensed in a charcoal canister, this canister is purged generally in a freeway with a high engine vacuum going on. the highest vacuum is achieved when you engine brake
Some models of the Yamaha R1 have an intentional flat spot in their fuel maps which happens to be right at the spot where testing happens, too.
In a similar vein, the Aprilia RSV4 kind of cheats at noise testing: in neutral, there is a baffle which flips down to dampen the exhaust note a bit. :)
Almost all supersport bikes coming into the US utilize both of these strategies. :)
I own a Ducati 999 that was lemonlawed because it would stall at stop lights. Super common and happened because of how lean the bikes had to run to pass US emissions.
Google said "random stalls" were kind of endemic to Ducatis. :P Didn't know it was related to the fuel mapping! I had a 1098 which would occasionally (maybe once per month) randomly stall at 0% throttle when braking to a stop. I had a full Termignoni system + race ECU, though. California doesn't do emissions testing on bikes, surprisingly!
I had to put a Power Commander on my R1 because of the aforementioned lean spot. The engine would "chug" at about 37mph (5.2k rpm in 1st gear), which unfortunately happened to be a very common cruising speed. Google showed lots of complaints for other years as well.
Just because they used various tools to attempt to meet EPA standards doesn't mean any or all of those tools are illegal. What you're describing sounds like either a smog pump and/or a charcoal canister. Both are legal and widely used means of controlling emissions.
The emissions guidelines, in your case, likely weren't being "gamed" so much as the manufacturers were just coming up with innovative and cheap ways of reducing emissions. Start/stop features on some newer cars are a way of doing this but this doesn't sound like someone "gaming" the system. If you're not very automotive savvy then you may have misunderstood what the technician was explaining or the logic/purpose behind the system.
What VW did though is completely different with regards to the software although not necessarily illegal until we have all the facts. Based on what the article says, it sounds like they developed a special "emissions mode" which went outside the normal operating parameters with the ultimate goal of reducing the emissions. That in and of itself is not illegal since it passed emissions that way. The illegal part probably comes from when it switch back into normal mode where it never would have passed emissions that way.
We can assume for one reason or another that the "emissions mode" is unsustainable for regular driving (for one reason or another) which is why it was only used when absolutely necessary to pass emissions.
Huh? They disable "emissions mode" during all driving either because a) it was bad for sales - perhaps one is unable to reach race car speeds in < 10 seconds; or b) they purposely chose not to build a compliant emissions reduction system and covered it up by specifically making the cars pass only during examination.
There is no apology to be made for them. Manufacturers are required to build sustainable systems, it's not optional. Unless the initial facts turn out to be wrong, this is clearly inexcusable.
I see what part of what I said made you confused. The "unsustainable" part of what I meant was that it caused some sort of undesired effect be it affecting performance or causing accelerated wear on components that could be costly to replace under warranty or some other condition.
Either way, I agree, VW did this intentionally and there is no question as to their motives behind it. I'm sure they'll be severely punished for it.
That sounds more like a Diesel Particulate Filter and regenerator ( https://en.wikipedia.org/wiki/Diesel_particulate_filter#Rege... ), which is pretty much the opposite of gaming. To keep the black clouds of soot that have sullied the name of diesel from forming, most modern diesels are designed to capture the soot until the engine gets warm enough to burn off the soot, at which point said soot is passed back through the engine and incinerated. Or, there's some mix of heater and catalyst to burn off the soot in the regenerator itself. You're basically holding onto the waste until you can efficiently deal with it in an environmentally clean manner.
The tech industry has been guilty of this in the past as well. Example: Nvidia and AMD drivers detected if you were running certain benchmarks or games, and would cheat by downgrading various rendering settings that had minimal effect visually.
Often this was a simple check to get the process's executable name; simply renaming the .exe would get you significantly different perf results.
Yeah that was how I first learned about this with ATI cheating on Quake III in 2001, as discovered by HardOCP. Here's a link to an article about it (original article doesn't seem to be around anymore):
PhysX's "CPU-only" codepath was intentionally built at a lower optimization level than their "with NVidia GPU" codepath for a while, leading to disproportionately lower performance than simply the lack of GPU kernels would create:
In this case defeat devices are specifically outlawed though, and VW have admitted creating them, so they are actually going to get punished, may put some people off.
Your link after .html: ?module=Notification&version=BreakingNews®ion=FixedTop&action=Click&contentCollection=BreakingNews&contentID=50913528&pgtype=Homepage
The 3rd link after .html: ?referrer=
In this case, while the links may lead to the same article, they are NOT the SAME link.
The urls are different for the one you submitted and OPs. Generally if you can remove extra query string params in the submission it helps the filter / deduper work better.
As I understand it, the new policy at HN is to allow duplicate posts to make sure enough readers see the article. I used to check for duplicates before posting, but now I don't bother.
I don't quite understand how the car can known it's getting an emissions test. I thought you just pulled up and revved the engine. Or do they plug the computer in nowadays?
Tests have fixed usage patterns. You detect those while total mileage is low, and you assume it's a test. After X thousand miles, you stop detecting. Job done.
eh, not really. In atlanta, it was once a year, around your birthday. Where I am, outside savannah, it's never. So my car would have no idea if it's being tested or not
I can second this, once a year in the Metro Atlanta area. Where I went to college they didnt do emission. Many classmates switched their registration so they didnt have to pay yearly emissions.
Where I live, they just plug a thing into the OBD-II port and go with whatever the car tells them. (I drive a '96 Honda Civic.) They don't test the exhaust directly.
In Wisconsin you drive to a specific testing facility and, when it's your turn, onto a testbed with rollers under the wheels. They spin endlessly without the car going anywhere until the test is over, when the rollers are locked so the car can drive off of them. During the test they attach a hose to the exhaust.
Engine revs in drive with no corresponding accelerometer output or change in GPS position should be a pretty solid indicator of "I'm in an emissions testing facility right now." Doubly so if there's an OBD-II reader attached.
Uhm, the emissions test you do every year (I guess in some US states is the same as in EU where you have to measure that yearly?) is different than emissions test that's done on each new model of car before allowing them to be sold and then entered into official specifications.
Remember there are restrictions like EURO5 etc. that impose higher taxes, city environmental taxes and even outright ban cars from being sold on the basis of these specifications.
First of all, that's not how it works.
Secondly, being in neutral and revving the engine seems like a pretty obvious red flag for "hey, maybe I'm being tested for emissions" in the scenario you mention.
Total speculation based solely on experience as a consumer (and I own a 2013 VW Golf TDI, so it affects me), but my guess is that the fix would be updated software to apply the stricter emissions controls all the time, presumably at the expense of engine performance.
EDIT: And reducing fuel economy, which is a huge selling point of the TDI in the first place. No idea "by how much" though, and typically TDI numbers are understated, so its possible that a reduction in economy will still be in line with their claims.
This is interesting. VW has already been performing a nationwide ECU reflash on all MkIV TDI cars this year. Was that part of this action, or was it the cause of this action?
This was a longstanding practice to make diesel engines more efficient while passing the official emissions test. There was a similar enforcement against Caterpillar and other truck makers in 1998:
What actually incentivizes a customer to take their car to a shop to get this fixed though? It's not causing harm to individual car owners, and it's not like they can get collections agencies to sieze them.
Seems like they're going to have trouble getting compliance here...
I've got a 2013 Golf TDI and was thinking about this as well. If it isn't a safety related recall, I'm not sure how you get people to comply aside from some other action related to, say, their next years registration (i.e. if your VIN doesn't have this fix applied, you can't reregister your car). Not sure if that's a thing, though.
I'd personally plan to take my car in "real soon now" to get the fix.
I have a 2014 Jetta TDI, and the thing I'm wondering is what the cost of the fix will be - not to me in dollars, since it would be covered by the recall - but rather, will this affect my fuel economy or performance in some other way? I'm just trying to figure out why they don't have the cars running in this lower-emissions mode all the time.
Yup, quite possibly thinking about bailing on the car sooner rather than later. I have no idea if this kind of thing significantly affects resale value, but I'm not sure I want to wait around to find out.
That seems like a big liability for them... I'm sure some enterprising lawyers are already plotting a class action. Consumer buys car after test drive and loves performance, but it turns out performance was a lie. They may have to do a buy back.
The vast majority of consumers won't notice. Some will be upset, because They bought the car for the specs on paper just to feel cool. Similar to how the fanboi segment of consumers by video cards and computers and stereo equipment.
Well, sure, if auto purchasers were at risk of massive fines if they received a vehicle where the manufacturer had done something that the average user wouldn't have the skill to detect, no one subject to the government imposing such fines would ever buy a car again, which would solve the problem quite completely.
OTOH, destroying the entire auto industry in the subject jurisdiction might not be considered an optimal means of resolving the problem. (And, indeed, might be so suboptimal to the population as to have catastrophic political consequences for the government imposing it.)
If these controllers were open source, drivers could decide on their engine settings themselves. That could be an interestimg strategy for VW as it would move responsibility to the drivers.
I love the look/feel/drive of a VW, but I will never again own one.
My parents bought a 2002 VW which I mostly drove and the maintenance costs were through the roof. There have been at least 3-4 recall notices, one time while parked on an incline, it rained and flooded the back of the car with water. When I went to VW, they said that I had to manually clean out some drainage underneath the car. How the hell am I going to do that?
Then the coolant leaks, engine belts, cracked radiator. You name it I probably had to get it fixed.
On the newer ones the high pressure fuel pump disintegrates and poops metal bits into the engine, requiring the engine to be replaced. That's why VW recently extended the warranty against the HPFP to, if I recall correctly, 100k miles.
Interesting, since here in EU the VAG group cars (Seat, Škoda, VW, Audi) are widely perceived as the most reliable and there's a huge amount of people buying nothing else.
I had a 2009 Wolfsburg Jetta 2.0t, assembled in Mexico I believe, that was a complete maintenance nightmare. I got out of it before the timing belt needed to be replaced and purchased a Toyota instead.
As was my German-built Corrado in the 90s.
Of course, is that stopping me from buying another one this year? Nope, it just took me 15 years ago to get over it.
This was true for much of the 2000s, but the new platform used from ~2009 onwards (the one implicated here) has been perfectly fine. The 2009-2016 Golfs get consistent Very Good/Good reliability ratings from Consumer Reports.
They're still not Honda, but they're now better than average.
The most common complaint is that repairs for German cars are much more expensive, but this may be an artifact of the supply chain for parts and not apply to Europe.
Individual anecdotes don't mean much. You can find objective data on car reliability on TrueDelta and Long-Term Quality Index. Those aren't true random samples but still pretty useful.
_My_ story is anecdotal but early 2000 VWs are known for being really shitty. this have this history. I heard they have gotten "better" but a bit too late for me to care about.
I had a 2001 Passat 1.8T (that I got used in 2003) had a slew of problem covered under the VW CPO warranty. Fortuitously enough, after that warranty expired, it ran like a clock for 8 years. (But I wasn't afraid to service it myself either.
I drive a mazda, and my car definitely runs rich (visible buildup on tailpipe, the exhaust smells like gasoline when the engine is cold), but it just passed its first emissions test (at 6 years old) showing no detectable gasoline. I wonder if there's some gaming going on there too.
Vehicles run rich when cold and at full throttle. No engine would pass emissions checks if they didn't run stoichiometric mixture during idle and low-throttle operation.
340 comments
[ 1.6 ms ] story [ 281 ms ] thread>"Using a defeat device in cars to evade clean air standards is illegal and a threat to public health," said Cynthia Giles, the E.P.A.’s assistant administrator for the Office of Enforcement and Compliance.
> California, the E.P.A. and the Justice Department are working together on an investigation of the allegations.
Though I hold similar pessimism to cmurf. If we can't even bring criminal charges against people that destroy the economy, I don't have high hopes for anyone being charged for destroying the environment (given the difference in priority they're normally given).
All those dealers and salespeople? There are a certain amount of cars that need to be sold. If VW is out of the mix, the demand is still there. The dealers can sell something else. I'm certain that Toyota and Ford can quickly come to some arrangement with those dealers, including any state legal issues.
In 2012, the EPA issued $252 million in fines, total. Kia & Hyundai were fined $300 million total in 2014.
I don't see them hitting VW with eighteen billion.
e: Eh, that might not be so unreasonable after all. In 2012, VW made about $28 billion in profit on $250 billion of sales.
And it’s not like only VW did this, every carmaker currently does this. It’s not going to change soon either.
Volswagen has over a period of time pumped a lot of this gas into the atmosphere and the fine ought to reflect the actual clean up damage. What is it going to cost to remove it and put the environment back to the way it should have been if they hadn't broken the law. That is what these sorts of fines ought to be based on.
Recall that VW Chairman Ferdinand Piech resigned earlier this year http://uk.reuters.com/article/2015/04/25/uk-volkswagen-ceo-c...
The board was quoted: "The members of the steering committee came to a consensus that, in the light of the past weeks, the mutual trust necessary for successful cooperation was no longer there"
What likely happened was that the EPA filed suit against VW in April, and in uncovering the evidence needed to support the suit, VW chair Ferdinand knew that he needed to go in order to let VW continue to be a company. Or, Ferdinand could have been the ethical one and blew the whistle.
Either way, let out the stink. Corporations aren't nearly the kind of flawless entities you think they are.
If anything that should go to show the lack of sophistication a lot of these projects have. There often is no project manager, no code reviews, and a messy codebase where snippets of very unethical logic can hide for years.
Indeed, this doesn't sound very German
Companies, at the time when "company" was still being defined, used to do anything to exploit people and kill the environment just so their owners got a return on investment.
Only through the past 100 years of laws, regulations, and cultural refinement have corporations overtly stopped so many abuses of power. Some of the refinement is purely psychological manipulation as well ("Clean Coal!") and companies are still doing awful things to individuals, societies, and the world at large.
Our current generation is blind to many of these abuses because we grew up inside the bubble of "friendly companies." Friendly companies know they have to maintain their image. Friendly companies know they must hide their evil deeds from law/regulation because public relations now matters more than beating people with sticks to increase their productive output (because companies are immortal after all, you can't have the public turning on you).
Here, they got caught, so they were being stupid.
You don't expect big, successful companies to be stupid (after all, they spend a ton of money to get the best CEOs they can).
The most fuel-efficient / eco ride is rather "boring" by the standards of car enthusiasts and reviewers and I guess the cars wouldn't be configured for that mode by default.
(Just a guess though.)
That said, cheating like this is really bad on a very large scale, and should probably face fines and maybe criminal charges, unfortunately discovery is likely to fall outside U.S. juristiction so it would be hard to prove enough to bring criminal charges against the appropriate managers and executives.
This really pisses me off. It doesn't surprise me I guess but it never occurred to me that a car manufacturer could get away with something like this for, apparently, 6 model years.
By only reducing emissions during testing, they can demonstrate better engine power and fuel efficiency while also claiming to meet the emissions requirements.
Harley Davidson and other are known to optimise for this test with movable parts in the exhaust pipes so these get much louder when the bikes goes faster than 50 Km/h.
I despise loud pipes, just frigging hate them. But I live in deer country (Santa Cruz mountains) and I've hit a deer at speed on the GS (did not wipe out, lifted the front end and had my front tire hit it square in the hind quarters, spun the deer around, I dropped the front wheel down and did a very shaky coast to a stop. My hands were shaking like a vibrator on steroids).
After that experience I really wonder if loud pipes would have scared the deer off. I tend to doubt it, I've not installed a louder pipe, but it's made me less pissed off at the loud pipe people. Not a lot less pissed off, but some.
BTW, shoutout to the Ninja 250 and especially the 500 version. I had two of the EX500's and those were by far my favorite sport bikes. Lots of torque, could pull any 600rr off the light (yeah, the 600 was blasting by me 2/3rds of the way down the block, but do you really want to ride a sewing machine? I don't. Loved my 500 twins.)
On a motorbike all it takes is a bump,and, you have to be lucky not to end up in hospital.
Btw in no way im for window rattling. However, EURO4/5, I would not be surprised if my vacuum cleaner was louder
I understand the point you are trying to make, and perhaps I wasn't very clear in my off-hand comment. I agree that overly loud bikes are annoying, however, as I stated before, sound is a necessary evil[0].
Do I believe that motorcycles should use straight pipes and increase their sound output? NO, in fact its quite annoying. However, louder bikes will get your attention.
In fact, in reference to [0], there is a standard that some vehicles had to INCREASE their decibel output because of less risk to pedestrians. This isn't an apples-to-apples comparison as this study was mainly geared towards electric vehicles, but it did state that vehicles should have an output of ~ 55dB for pedestrian safety (page 102).
Secondly, I couldn't find good stats on motorcycle decibel output, but I did find a study of some motorcycles and their average output[1]. What I learned is that most bikes are fairly equal with regard to output and all are at, or above the, legal limit[2].
I took a single bike you pointed out `Honda CBR250R` and was curious how the noise output performed to a Harley: `Honda CBR250R`: [3] - With dB-Killer fitted: 86 dB @ 4,250 rpm - Without dB-Killer fitted: 94 dB @ 4,250rpm
2006 Softail Standard 1,400 cc: [4] - 97 decibels at idle - 102 decibels at cruising speed - 111 decibels revved
So what it appears to me is that most motorcycles are `roughly` the same decibel output and that having a vehicle that outputs sound to make yourself known to other riders is beneficial. Should you be increasing the sound trying to be cool? No, I don't think so. In fact its annoying when the 5 Harleys are sitting outside my window on Friday night revving their engines to be "cool".
[0] - http://www.motorcycledaily.com/wp-content/uploads/2013/01/Qu... [1] - http://audiologyworld.net/img/rnhposter.pdf [2] - http://www.gencourt.state.nh.us/rsa/html/XXI/266/266-59-a.ht... [3] - http://www.autoevolution.com/news/honda-cbr250r-gets-street-... [4] - http://lic.abateflorida.com/Library/Library/cycle_news__nois...
That's not a good statement. Just because a number is logarithmic does not make sound logarithmic...Here is a video that shows two different exhaust with similar dB output: https://www.youtube.com/watch?v=Ax6W-V9bsmg
As a side note, opening a can of coke will record 101.5 dB from one meter away: https://www.youtube.com/watch?v=uAd2BUB6XqQ
> Two, you are comparing factory exhausts on the Harley meant to comply with noise regulations with top of the line aftermarket race exhausts for the Honda (which is probably as loud as you could make the Honda without removing the pipes entirely). They are not anywhere near each other - and the data in [1] really makes that point,
Honda are subject 1 and 3, Harley are 5 and 6.
Subject 1 - 105 dB A, Subject 3 - 99 dB A.
Subject 5 - 101.8 dB A, Subject 6 - 106.7 dB A.
The two Hondas are not the same one you mentioned in your original post, However, stock exhaust is 72dB at idle and 86dB at half throttle on Honda CBR250R. http://www.motorcycle-usa.com/2013/03/article/2013-honda-crf...
With the level of acoustic engineering that goes into modern vehicles specifically to block out external noise, combined with radio / in car entertainment, relying on other drivers being able to position you from audio is a bad idea. Now if bikes were to be fitted with cell phone jammers, that I could get on board with.
its the cagers that are the problemo, thus the comment
(FWIW, I hate loud exhausts)
Electric vehicles are sustainable, motorcycles are death traps that can't be made safer (said as an ex-owner of a Katana, and both a Yamaha R1 sport bike and Roadliner cruiser).
I'll be happy when motorcycles are electric, and therefore silent. If your vehicle can't carry you safely without being unnecessarily noisy, then it just shouldn't be on the road.
When the answer is 'ban it' there is something wrong.
I also agree that you don't have to make your bike EXTRA loud to be noticed but there is a perceived safety in sound. And if majority of the sound is exiting towards the back, there might a point to be made that the decibel level should increase to "hopefully" make the person in front of you aware.
All my bikes are quiet, even my Buell (relatively speaking). I have installed extra loud horns on them and I'm not afraid to use them. That's what horns are for: to say "I AM HERE", nothing more, nothing less. Save your engine for moving the bike forward, not making all of us bikers an anathema to civil society.
However, as I answered in a response to one of the other commenters, sound is an essential element in bringing awareness to yourself.
`All my bikes are quiet, even my Buell (relatively speaking)` - From what I've found in my short research is that most bikes are in similar decibel level output (within similar engine capacity) and that they are all fairly loud. Clearly there's something to that.
But I degrees, I never meant to say that you have to be extra loud to be an ass, I was merely pointing out that sound is an element of awareness, like your horn or the headlight.
I dont like loud bikes driving by and waking them up :-/
I didn't meant that you had to be extra loud or replicate the idiotic behavior of our neighborhood bikers. I was merely pointing out that loud sounders are safer. I had a more detailed reply above.
So right, too much noise = bad. Just enough sound = maybe good.
You make a valid point "... implying that drivers have less need to perceive small bikes...or other cars, apparently."
As I stated above, but will re-iterate because its a valid reply here, there seems to be a necessary of roughly 55db produced by a vehicle to ensure safety for pedestrians and other vehicles. [0]
My initial comment was incomplete: it's not okay to have an extra loud bike to be "cool", however, it is important to have a high enough decibel output that other people can hear you. Most bikes produce similar dB off the manufacturing plant for a reason and electronic vehicles are required to output more sound to be safe.
So no, i'm not implying that drivers have less need to perceive small bikes or other cards. I'm implying that all vehicles should produce the necessary decibel output to bring attention to themselves.
[0] - http://www.motorcycledaily.com/wp-content/uploads/2013/01/Qu...
It's not true this helps on the highway. In my car, which has double glazed glass, you can't hear a bit until it's right outside the window.
When I'm walking along with the dog and kids, an open pipe Harley riding past is particularly not safe, because it scares the crap out of them.
One idling Harley is louder than a thousand idling Volkswagen diesels.
Is this an error in the article or is creating ozone a bad thing?
https://en.wikipedia.org/wiki/Ozone#Ozone_air_pollution
At the ground level, yes.
https://en.wikipedia.org/wiki/Ozone
"Ozone is a powerful oxidant (far more so than dioxygen) and has many industrial and consumer applications related to oxidation. This same high oxidising potential, however, causes ozone to damage mucous and respiratory tissues in animals, and also tissues in plants, above concentrations of about 100 ppb. This makes ozone a potent respiratory hazard and pollutant near ground level."
And, also, heavier than air.
(Article is from last year - it's just something I found on google just now - but representative.)
i haven't done one in over a decade because i lease my cars as a business expense.
also, ca has 'test-only' smog centers which do not perform repairs - if you fail there, you have to get your car tested and repaired somewhere else.
needless to say ca highly incentivizes you to buy new clean cars. it quickly becomes very expensive to fix an old, polluting car under this regime. imagine how fast the bills can pile up if the first or second fix doesn't work. with new econo class cars available for ~$100/month on finance or lease, it doesn't really make sense to keep an old clunker around unless it's a collectible.
"Currently, smog inspections are required for all vehicles except diesel powered vehicles 1997 year model and older or with a Gross Vehicle Weight (GVWR) of more than 14,000 lbs, electric, natural gas powered vehicles over 14,000 lbs, motorcycles, trailers, or gasoline powered vehicles 1975 and older."[0]
[0] https://www.dmv.ca.gov/portal/dmv/detail/vr/smogfaq
i've seen this also when having fire extinguishers inspected; ones that are only a year or so old are also only visually inspected only.
The drive-by inspection doesn't require the co-operation of the driver or car, so is harder to game by detecting you are being tested.
I'm not shocked that California is a part of this.
I suppose one could say that being more concerned with the more directly harmful and smog forming emissions(NOx and PM) over CO2 would constitute 'bias' against diesels. But, conversely, there's a rather compelling argument that the more lax European diesel regulations spurred diesel adoption and protect their domestic manufacturers.
https://www3.nd.edu/~jthurk/Papers/MMT.pdf
In the case of Volkswagen, the TSi engines are a much better buy than the TDi engines. Better power delivery, clean running and nearly as good fuel economy.
Used to be.
It's similar to the feeling I got when I waited in line for an hour to have my Miata smog-checked at a busy urban test station, and then choked on diesel exhaust from a dump truck when I made the mistake of driving away with the top down. CARB is the poster child for "Doing something just to say we're doing something."
With cars going electric, its a bit of a moot point, except for the part where pressure needs to be applied on heavy trucks now (hopefully pushing them to natural gas from diesel until energy storage catches up).
You could argue that equipment checks are in place to prevent the very situation described in this article, where people might install shady aftermarket hardware to game emissions tests, but as we've seen, the aftermarket is not where the problem actually lies.
Wow, judging by the down-votes, people don't seem to realize how expensive CARB deliberately makes it to own an older car, regardless of how clean its emissions are.
EDIT: To further demonstrate that it's all about money and not about smog, you can get a "Repair Cost Waiver"[1] if you've spent at least $650 (on CA-approved parts, of course), and they'll approve your polluting car, no problem. All they really want is that $650 in the pockets of their car industry buddies and $XYZ worth of repeated tests in the pockets of the test stations.
1: http://www.bar.ca.gov/Consumer/Referee/Referee_Centers.html
I upvoted you even though I disagree with you for what its worth.
You're an edge case. Most people with older cars no longer maintain their emissions controls. The older the car, the more likely it is that its polluting. Is it fair? Not at all. You're just swept up in the process.
I have had cars in the past that OBD2 reported as operating correctly, that easily passed smog/inspections, that probably weren't operating as the EPA intended.
Chasing a problem like that around is a waste of everyon'e time and money. Environmental regulatory agencies really need to do a better job considering the 90/10 or 80/20 rule (the last 20% of whatever you're optimizing will consume 80% of the resource).
If it's to cover modified cars, those are a trickier situation. It's easy for some to game the system so that it "passes" on the magic day and then fails the other 364 or 729 days in the cycle when it's actually being driven.
In either case, it seems like the expense of operating and staffing gas sensing stations, rolling road dynos, etc. Probably better to just turn a blind eye to that case as well.
Nevermind the fact that California has no safety inspection, unlike many Eastern states in particular. It's fairly silly to call CA the "gestapo" although they are more aggressive about emissions than anyone else, as you mentioned.
I am a driving and motorcyclist enthusiast, and have modified cars and regularly participate in track days. Somehow I've never had a problem with CA emissions, nor have most of my like-minded friends. It's just not that bad, and it does a lot of good.
Vehicles 1999 and older still get the tail pipe probe and dyno portion as well as the OBDII (if they have OBDII).
[0] http://www.bar.ca.gov/Consumer/New_Smog_Check_Test.html
[1] http://www.smogtips.com/new-smog-law-ab-2289.cfm
The shop owner usually, almost always, buys the $100.00 Motor Emissions manual.
The cheap shop owner should buy OnDemand5(Mitchell Manual Smog Emission) subscription/publication. They don't because they are cheap, and CARB only requires one reference manual for customers, and technicians.
The problem is Motor Publications is filled with errors that send thousands of customers home with failed Smog Checks.
I have found so many errors in Motor publications, it's comical. I have numerous emails, where I am literally arguing with, I believe, a secretary, over errors in their manuals. I have one email when the person I'm communicating with doesn't know the difference between Naturally Aspirated(Carburated) v.s. Fuel Injection. It's beyond frustrating, and I hope they get sued!
If you live in California, and your car doesn't pass the visual smog check, it's probally not you--it's errors in Motor Publications?
I have found errors on older Toyotas, and Volvos. Just the two autos I happen to own? What are the odds of that? They failed my vechicles, until I went to a shop that had Mitchell manuals, and I presented the Techs with a Printout of the Correct Emmission information.
(Motor Emission manuals--If you are listening; please clean up your books? It's beyond frustrating to fail a smog test because of your sloppy research! I will show the world my frustrating emails--if necessary?)
(CARB--if you are listening, require every shop to have access to two (2) separate Emmission manuals from different entities?)
And no--1988 Toyota trucks, 2wd, naturally aspirated(Carburator) do Not require a MIL light.
I literally tore apart the dash looking for the missing light. There was no light. There was no plug for a light. I literally thought I was going crazy. I was so frustrated, I forget to set the emergency brake and the truck rolled out of the garage. I'm lucky I wasen't on a hill and no one got hurt. I did need to buy a $200 bumper though. I'm still thinking about taking the shop to small claims court, but don't think it's worth the effort?
So, if you live in California, and fail Smog--ask questions. Don't just bring it to another Smog testing station praying it will magically Pass.
The type of fuel delivery has nothing to do with whether it is naturally aspirated or not. A NA engine can have fuel injection and a supercharged engine can have a carburettor.
[1] http://www3.epa.gov/otaq/cert/documents/vw-nov-caa-09-18-15....
This also pretty much guarantees that I will never buy another VW.
Good luck with that.
While this is a different case, it struck me then that the emissions guidelines were being gamed by manufacturers. We're regularly reminded that barriers will be circumvented; what is the correct approach here? Like performance enhancing drugs in sports, too stiff of a fine and manufacturers are encouraged to find more subtle ways to beat the system, unenforced you leave a polluting industry to destroy our environment..
Just like sports, companies will still cheat. When punishment doesn't work, the answer is rarely more punishment.
http://www.nytimes.com/2015/09/17/opinion/nicholas-kristof-w...
Actually, in order to come up with the $2B penalty, the gov't determines the number of fraudulent Rxs, then hits the manufacturer with triple damages (this is typical).
J&J would have been better off financially had they never committed the fraud they did.
Even if they're just breaking even, it's a kind of loan - they had the gain a long time ago, and pay the costs much later. If you're a risky business, that's potentially worth a lot, since investors might be hard to find.
And if you account for that you need to account for the asymmetry of risk due to bankruptcy protections - even if the average payout is negative, fines are effectively capped at what the firm can pay, so the effective expected payout may still be positive. (Assuming those making this decision escape personal liability).
Cruel, but I bet it's effective.
In other words, you would cause a lot of collateral damage instead of taking it directly from shareholders via a large fine.
A prison sentence for a parent is not just hurting the kid more, it's also much harsher on the parent. You're not only taking away their freedom, you're also taking away their kid. In effect, that is differential treatment as well. But I will admit that I'm not comfortable with this line of argument either.
The case of auto makers breaching environmental rules is much simpler though as a large fine that does not cause factory and dealership closures or price hikes is better in every imaginable way.
So what happens when punishments begin to show an even stronger racial bias. For example, the argument that a white offender is safe to release because they are more likely to get a job which reduces their chance of committing a crime. Never mind that they are more likely to get a job because of institutionalize racism in our society.
>You're not only taking away their freedom, you're also taking away their kid.
A prison sentence for a rich individual hurts their income far more (and they are less likely to engage in crime once they are out due to higher education and better ability to find employment), so rich people should only be given a fraction of the sentence... the conclusion using this line of reasoning do seem to end poorly.
>The case of auto makers breaching environmental rules is much simpler though as a large fine
Except it attached a price tag to breaking the law, which fundamentally changes how businesses approach the law. Imagine what would happen if every crime was fined a fraction of what it earned you.
That is but one possible argument of many. A judge could also make the case that locking up hugely more members of one racial group than of others destroys the social fabric of society, creates even more crime in the next generation and is ultimately worse for everyone.
So yes, you could ask many questions of that sort and you are right that giving judges room to weigh individual circumstances can go both ways. In my opinion, not having that wiggle room is cruel and relies on a completely unjustified confidence in the ability of law makers to forsee all the situations that might come up.
>Except it attached a price tag to breaking the law, which fundamentally changes how businesses approach the law. Imagine what would happen if every crime was fined a fraction of what it earned you.
Banning an auto maker for 12 months in one particular country has a price tag too. Every punishment of a corporation can be distilled down to a mere price tag. Whether or not the price tag of a ban is higher or lower than any fine depends on the amount fined.
There are many problems with outright bans. It is a very inflexible and crude tool. It does not allow for a gradual and measured punishment that fits the extent of the violation. It does not bring money into government coffers or into victims pockets. It cannot be applied equally to every company in the same way if at all. You cannot simply shut down banks, utilities or OS vendors without destroying the entire economy. We do need some degree of pragmatism that limits collateral damage.
Also, we have to acknowledge that corporations are not people after all. The corporation doesn't take the decision to violate some law. Executives do. So if you want to go beyond a price tag for certain kinds of violations then you need criminal prosecution of individual executives on top of fines.
http://www.nytimes.com/2015/02/04/business/when-a-company-is...
Agreed. If auto makers face the risk of significant fines and/or penalties they will have to spend more on compliance. The worst thing for innovation is to create an environment where engineers are effectively being managed by lawyers and accountants.
Still I get your point: manufacturers are clearly going to optimize based on the measured metrics. How do we know those metrics are meaningful in the overall system.
When engines are colder, they burn less efficiently and produce "worse" emissions. A system that treats the warmup period differently than the steady-state of running a hot engine is potentially quite reasonable.
That's not what EGRs do.
EGRs take exhaust, which is relatively inert (combustion having already taken place) and injects it into the combustion chamber to lower combustion temperatures. The reason you want low temperatures is that NOx (nitrogen oxides) form at high temperatures.
https://en.wikipedia.org/wiki/Exhaust_gas_recirculation
"In internal combustion engines, exhaust gas recirculation (EGR) is a nitrogen oxide (NOx) emissions reduction technique used in petrol/gasoline and diesel engines. EGR works by recirculating a portion of an engine's exhaust gas back to the engine cylinders. This dilutes the O2 in the incoming air stream and provides gases inert to combustion to act as absorbents of combustion heat to reduce peak in-cylinder temperatures. NOx is produced in a narrow band of high cylinder temperatures and pressures.
In a gasoline engine, this inert exhaust displaces the amount of combustible matter in the cylinder. In a diesel engine, the exhaust gas replaces some of the excess oxygen in the pre-combustion mixture.[1] Because NOx forms primarily when a mixture of nitrogen and oxygen is subjected to high temperature, the lower combustion chamber temperatures caused by EGR reduces the amount of NOx the combustion generates (though at some loss of engine efficiency).[2] Gasses re-introduced from EGR systems will also contain near equilibrium concentrations of NOx and CO; the small fraction initially within the combustion chamber inhibits the total net production of these and other pollutants when sampled on a time average. Most modern engines now require exhaust gas recirculation to meet emissions standards."
Personally I like internal egr because external egr systems have a tendency to clog in either the passageways or the solenoid controlled valve. EGR valve sticking is a common cause of cars stalling when slowing to a stop after cruising at medium-high speed. And even without the stalling egr is a common cause for check engine lights and smog test failures.
Not necessarily gamed - the measuring just needs to factor it in. e.g. (Rather anecdotal) I know there are cars programmed to capture emissions in a filter & then automatically clear that when the car reaches high speeds (freeway). Makes sense in a way...you'd rather have the car expelling the crap on the freeway than city center. That mechanism is apparently a big problem here - I live in a place where the cars never reach freeway speed so they keep clogging (so I'm told).
In a similar vein, the Aprilia RSV4 kind of cheats at noise testing: in neutral, there is a baffle which flips down to dampen the exhaust note a bit. :)
I own a Ducati 999 that was lemonlawed because it would stall at stop lights. Super common and happened because of how lean the bikes had to run to pass US emissions.
I had to put a Power Commander on my R1 because of the aforementioned lean spot. The engine would "chug" at about 37mph (5.2k rpm in 1st gear), which unfortunately happened to be a very common cruising speed. Google showed lots of complaints for other years as well.
I commuted to work in San Francisco on literbikes, but on weekends I would head south and open them up.
The emissions guidelines, in your case, likely weren't being "gamed" so much as the manufacturers were just coming up with innovative and cheap ways of reducing emissions. Start/stop features on some newer cars are a way of doing this but this doesn't sound like someone "gaming" the system. If you're not very automotive savvy then you may have misunderstood what the technician was explaining or the logic/purpose behind the system.
What VW did though is completely different with regards to the software although not necessarily illegal until we have all the facts. Based on what the article says, it sounds like they developed a special "emissions mode" which went outside the normal operating parameters with the ultimate goal of reducing the emissions. That in and of itself is not illegal since it passed emissions that way. The illegal part probably comes from when it switch back into normal mode where it never would have passed emissions that way.
We can assume for one reason or another that the "emissions mode" is unsustainable for regular driving (for one reason or another) which is why it was only used when absolutely necessary to pass emissions.
There is no apology to be made for them. Manufacturers are required to build sustainable systems, it's not optional. Unless the initial facts turn out to be wrong, this is clearly inexcusable.
Either way, I agree, VW did this intentionally and there is no question as to their motives behind it. I'm sure they'll be severely punished for it.
Often this was a simple check to get the process's executable name; simply renaming the .exe would get you significantly different perf results.
http://techreport.com/review/3089/how-ati-drivers-optimize-q...
http://semiaccurate.com/2010/07/07/nvidia-purposefully-hobbl...
https://news.ycombinator.com/item?id=10239985
There's also another submission 15 minutes after OP's submission too.
https://news.ycombinator.com/item?id=10240106
Your submission uses: http://www.nytimes.com/2015/09/19/business/volkswagen-is-ord...
The OP's link after .html: ?_r=0
Your link after .html: ?module=Notification&version=BreakingNews®ion=FixedTop&action=Click&contentCollection=BreakingNews&contentID=50913528&pgtype=Homepage
The 3rd link after .html: ?referrer=
In this case, while the links may lead to the same article, they are NOT the SAME link.
edited: to make url differences more visible
Some emissions places also do the tube-up-tailpipe check, but the car could adjust exhaust output if it has an active OBD-II connection.
Engine revs in drive with no corresponding accelerometer output or change in GPS position should be a pretty solid indicator of "I'm in an emissions testing facility right now." Doubly so if there's an OBD-II reader attached.
Remember there are restrictions like EURO5 etc. that impose higher taxes, city environmental taxes and even outright ban cars from being sold on the basis of these specifications.
> The allegations cover roughly 482,000 diesel passenger cars sold in the United States since 2009.
EDIT: And reducing fuel economy, which is a huge selling point of the TDI in the first place. No idea "by how much" though, and typically TDI numbers are understated, so its possible that a reduction in economy will still be in line with their claims.
http://www2.epa.gov/enforcement/caterpillar-inc-diesel-engin...
And against Ford in 1998:
http://www2.epa.gov/sites/production/files/2014-06/documents...
along with a clear ruling that defeat devices were illegal.
Seems like they're going to have trouble getting compliance here...
I'd personally plan to take my car in "real soon now" to get the fix.
I'm in CA, just had to renew my registration and get my car smogged a couple months ago (its a 2013). It passed, of course.
How would fining the end users solve the problem?
That's idiotic.
This position has not been thought through.
OTOH, destroying the entire auto industry in the subject jurisdiction might not be considered an optimal means of resolving the problem. (And, indeed, might be so suboptimal to the population as to have catastrophic political consequences for the government imposing it.)
I don't see how passing the costs along to future car purchasers is better than extracting the costs from the people who were actually harming others.
My parents bought a 2002 VW which I mostly drove and the maintenance costs were through the roof. There have been at least 3-4 recall notices, one time while parked on an incline, it rained and flooded the back of the car with water. When I went to VW, they said that I had to manually clean out some drainage underneath the car. How the hell am I going to do that?
Then the coolant leaks, engine belts, cracked radiator. You name it I probably had to get it fixed.
Never again.
Here's the 400-page-long forum thread on that defect: http://forums.tdiclub.com/showthread.php?t=308323
They're still not Honda, but they're now better than average.
http://www.truedelta.com/car-reliability
http://tradeinqualityindex.com/reports/Volkswagen.html
I don't believe I've ever seen a factory tuned vehicle run less than 16:1, most are 17 or 18 : 1